Calibrate the battery cell

First of all, the test voltage to zero, the machine can not start naturally, can not use power when charging (the battery light does not shine).

Disassemble the battery, more or less talk about the situation inside the battery.

Battery in a total of 9 can be placed 18 millimeters in diameter, length 65 mm core CGH18650 models the location of lithium batteries, Panasonic’s 22 batteries in parallel, three groups of series (OK, then my new Dell Inspiron 6000 Battery, the same, it appears that is 6), there is a very fine control with a single chip – the protection of the circuit, the circuit to the computer a total of five output contacts, respectively, are negative, the clock and data.

First of all, check the sticky in the battery temperature detection probe (temperature resistance), and temperature protection insurance, are also normal. Test-retest the battery voltage of each group, in which two sets of battery voltage of 3.8V, normal; a Dell Latitude D820 Battery voltage of 0V, appear to have lapsed. The total battery voltage of 7.6V, then the failure of the battery pack has not yet open, then measuring the internal resistance was very small, almost in a state short-circuit.

First of all, failure to deal with Dell Inspiron 6400 Battery, battery repair based on previous experience, the failure of the battery may not be completely damaged, can be activated through a number of methods, in particular the performance of state for the short-circuit the Dell XPS M140 Battery. The voltage of the battery to 0 with one end connected to the circuit board off line to avoid damage to circuit boards in operation. Open-circuit battery voltage after the re-survey, is still 0V, ruled out the possibility of short-circuit boards.

For short-circuit the battery failure, the method is more effective high-voltage electric current moment method, using the old Sony Power Supply (my back-up power), 16V maximum 3A output string on the multimeter (a tributary of the current file 20A), first negative power supply Even with the battery anode, and cathode power multimeter then red table pen, table pen with black multimeter battery cathode touch, speed, faster as far as possible, the former two degrees to see the multimeter has reached close to the 2A (moment) and the third on only 0.4 A about an immediate stop, measure the Dell XPS M1530 Battery voltage has been restored to about 3V, the internal battery short-circuit that point has been an instant high-current boil (If you do not damage the battery to stop immediately, even if so, battery life and capacity have been the impact, if conditional, or recommend replacement, but if the replacement, then try to replace the entire battery pack are). However, the Dell Inspiron 1545 Battery need to be a separate charge (if the battery charge of the whole group, this will result in the other two groups had mesenchymal cells), plug in the charger to start charging ammeter to monitor during the charge current to 500mA or so, current for the 3.6AH battery pack is small, but the charger is the charge current is limited and a small current to the HP pavilion dv9000 Battery charge is good for the resumption. After about six hours, the charger showed the battery is already full, continue to re-charge for about two hours, remove the battery, measure voltage has reached 4.2V, with bright halogen bulb in the flashlight (3V, 500mA) to discharge its , bulb sharp discharge current of 700mA, the battery pack that has been basically restored, continue to discharge until the battery voltage down to 3.8V, the purpose of the two groups with the same battery voltage, charging time together so as not to overcharge the Back to the whole battery pack battery circuit welding.

Since the HP pavilion dv8000 Battery voltage while the circuit board there is no output, then, surely have damaged circuit boards, after observation, negative input circuit board (take battery) output (then output contact) is directly connected, and the positive input and output of by a high-power thyristor control, the thyristor remains cut-off state, that is, the control circuit has not been output control signals to the SCR control terminal, or simply the SCR has been destroyed. (Measured after the control signals that I did not) because I do not have the ability to repair single-chip microcomputer. IBM to take into account the protection of the BB more perfect, is about to run out of battery power will automatically shut down when, this battery is intended to be used for entertainment, therefore, need not be too concerned about, so I decided to shake the hp Battery Protection circuit, directly depend on BB’s protection circuit. SCR is in the input and output pin (that is, cathode circuit board input and output pin) between the solder on a small 2A fuse, fuse 2A select the reason is based on current usage, the largest in the computer power consumption , the current does not exceed 1.9A, 2A capacity sufficient unusual circumstances (for example, short-circuit accident) but also to ensure that the fuse of the time, but also play a role in protection.

In fact, directly to the SCR control terminal so that it can also be a high turn-on, but taking into account the current the battery must be a reason to burn, and the reasons for the identification of protective measures taken before or better in order to avoid greater loss.

Well, the battery power has been the first non-stick, and on the machine to try it! Normal boot, plug in the power immediately after the charge on the flashing lights are up, the way when charging the Sony VGP-BPL9 Battery with a random look at battery information management software, was also displayed, the battery circuit board This shows that the single chip is still working.

Batteries Sony VGP-BPS4 Battery is a Panasonic, the time the factory in June 2000, the first time in October 2000, the design capacity of 38.88Wh, the current capacity 38.88Wh, is charging cycle: 0 times.

Oh, do not know how to engage in, the Sony VAIO VGN-FZ Battery may be burned when burning confused, even cycles to the zero, Now it maybe a new battery.

About the Author

Laptopbattery-sale.com offer all kinds  brands of Laptop Battery such as acer laptop battery, asus laptop battery, apple laptop battery, compaq laptop battery, dell laptop battery,fujitsu laptop battery,hp laptop battery, ibm laptop battery, sony laptop battery, toshiba laptop battery.

http://www.laptopbattery-sale.com/sony/sony-vaio-vgn-fz.htm

Top Selling Battery Tender 12 Volt 20 Amp High Frequency Gel Cell AGM Battery Charger

Black & Decker EHC650 2-Speed Food Chopper with 3-Cup Bowl $18.87 This electric food chopper accomplishes a food processor’s principal function of chopping and mincing without having to haul out the big machine. It’s just 8 inches high and 4-3/4 inches in diameter, and its 3-cup bowl is ample for many chores in a family household and most chores in a one or two-person household. At 150 watts, the motor is powerful enough to chop or mince vegetables, fruits, herb…

Fred and Friends Salt and Pepper Set $6.57 Fred & Friends Salt + Power Battery Shaped Salt and Pepper Shakers….

Digital Microwave Oven Leakage Meter $34.95 Here’s a unit which will give you not only accurate digital readings of the amount of leakage from microwave ovens, but it also provides an audible “beeping” alarm and red flashing light when it senses microwaves above the 5 mW/cm² danger threshold! Ergonomically designed to fit comfortably in your hand, it is so easy to use: just press the ON button, then press and hold the auto range ZERO butto…

Chaos Theory: Splinter Cell 3 Soundtrack $6.17 Soundtrack CD featuring extended versions of the themes from the game….

Rapid Car Charger with IC Chip for Sprint, Alltel HTC Touch Diamond (CDMA) Smartphone $0.01 Rapid Car Charger with IC Chip for Sprint, Alltel HTC Touch Diamond (CDMA) Smartphone…

2 Rapid Car Chargers with IC Chip for AT&T LG Shine CU720 $0.35 …

Mr Beams MB360 Wireless LED Spotlight with Motion Sensor and Photocell – Weatherproof – Battery Operated – 140 Lumens $19.41 …

Black & Decker Pivot Vac 18V Cordless Pivoting Hand Vac, PHV1810 $48.99 Exclusive 10 position pivoting nozzle provides ultimate vacuuming accessability up high, down low, and in between. Integrated extension nozzle for 50% more reach in tight areas. 18V of power and strong motor provides 35% more suction power. Cylonic action filter stays clean so that suction power stays longer. EZ Clean wheel system instantly improves suction power. 3 stage filtration provides clean…

Streamlight Nano Light Miniature Keychain LED Flashlight Truly tiny, the Nanolight is a weatherproof, personal flashlight featuring a 100,000 hour life LED. Includes a non-rotating snap hook for easy one handed operation when attached to a keychain….

The Sum of His Parts $1.99 …